noisy clutch mk 3 fiesta

Honest John Back Room » Technical matters
View Threaded
Sun 18 Feb 2007 19:21
noisy clutch mk 3 fiesta - milkyjoe
hi, along with my warning bulb (earlier posting) the clutch was making a bit of a racket after a long run today (idling in nuetral) but seemed quiter when i dipped the clutch pedal it doesnt slip at all when travelling so i dont suppose its the friction plate should i ignore it or get the clutch replaced and if so do the kits contain all the bits apart from the friction plate or will i need to go to a breaker for additional parts
Reply | Report as offensive | Link
Sun 18 Feb 2007 20:48
noisy clutch mk 3 fiesta - stuartl
Dry or knackered thrust bearing!

Fairly easy change and only a few quid
Reply | Report as offensive | Link
Mon 19 Feb 2007 01:01
noisy clutch mk 3 fiesta - milkyjoe
i looked in the haines manual about the clutch,seems you have to dis the transmission and alsorts to get into the clutch i hope there is an easy way to fix it could you elaborate a bit as to how i remedy the thrust bearing thanks
Reply | Report as offensive | Link
Mon 19 Feb 2007 08:11
noisy clutch mk 3 fiesta - Collos25
Remove the gearbox and the bearing is sat in the middle ,but while its out you may as well replace the clutch and pressure plate. Its like all work on a car if you have the correct tackle its a doddle .
Reply | Report as offensive | Link
Mon 19 Feb 2007 12:24
noisy clutch mk 3 fiesta - RichardW
To my mind this sort of noise is unlikely to be the release bearing - this is not loaded when the clutch is not pressed so unlikely to be noisy - it only gets loaded when the clutch is pressed, and that is when it usually complains. This sort of rattling is more likely to be play in the input shaft bearing or something - when you depress the clutch the box stops going round and the noise stops. I would try changing the gear oil first, but the box is probably on its way out - however, a bit of a rattle at idle is hardly reason to change the box....
--
RichardW

Is it illogical? It must be Citroen....
Reply | Report as offensive | Link
Mon 19 Feb 2007 12:50
noisy clutch mk 3 fiesta - Cliff Pope
See what difference it makes at idling with the clutch pedal fully released, pressed to the point of contact with the thrust bearing, and then fully depressed.
If it is the thrust bearing it will be nosy when actually used, but quiet otherwise.
It may be possible to squirt in a bit of lubricant, if there is an access hole by the operating lever or a ventilation slot. Don't overdo it, but a shot of spray grease might help.
Reply | Report as offensive | Link
Mon 19 Feb 2007 17:59
noisy clutch mk 3 fiesta - mfarrow
When it next does it, have someone or a block of wood pull on the clutch pedal whilst you pull the clutch fork on the gearbox towards the front of the car. It should move fairly easily, and as it does so, it will pull the bearing away from the clutch completely. If the noise stops, that's your culprit. Otherwise it's the input bearing.

--------------
Mike Farrow
Reply | Report as offensive | Link
Mon 19 Feb 2007 20:20
noisy clutch mk 3 fiesta - stuartl
>>>>>To my mind this sort of noise is unlikely to be the release bearing - this is not loaded when the clutch is not pressed so unlikely to be noisy - it only gets loaded when the clutch is pressed,


A release bearing will make a noise when unloaded if it is dry. It can actually appear to be quieter when in use as it is compressed.
Reply | Report as offensive | Link
Mon 19 Feb 2007 21:43
noisy clutch mk 3 fiesta - DP
This is perfectly normal on mk3/4/5 Fiestas. HJ mentions it in his car by car breakdown for these cars.

I quote "Some clutch noise (release bearing) at idle is common. Should go when in gear. Any noises when on move from gearbox? Run away. "

Our 1.4 does it, the three others we looked and and test drove did it, and our old Zetec-S did it. Nothing to worry about. These 'boxes are just noisy in neutral.

Cheers
DP
Reply | Report as offensive | Link
Tue 20 Feb 2007 09:15
noisy clutch mk 3 fiesta - madf
"the clutch was making a bit of a racket after a long run today (idling in nuetral) but seemed quiter when i dipped the clutch pedal "

My 1 year old Mark5 Fiesta was like that at 4k miles. and at 30k miles when I sold it...

As DP says, it's standard...
madf
Reply | Report as offensive | Link
Tue 20 Feb 2007 10:26
noisy clutch mk 3 fiesta - milkyjoe
would topping up the gear box with gear oil help matters? as far as i know its not leaked any but it is a high mileage car
Reply | Report as offensive | Link
Tue 20 Feb 2007 10:37
noisy clutch mk 3 fiesta - Dynamic Dave
would topping up the gear box with gear oil help matters?


Not if it is the clutch that's noisy. The clutch is outside the gearbox.
Reply | Report as offensive | Link
Tue 20 Feb 2007 11:22
noisy clutch mk 3 fiesta - madf
Fwiw , I found depressing the clutch and then releasing it again when stationary in neutral sometimes reduced the noise levels..

I also changed the oil on son's Mark3 Fiesta - not as noisy as mine--- and found it made NO difference to any rattles at idle..


I found the noise very annoying at traffic lights....
madf
Reply | Report as offensive | Link
Sat 29 May 2010 22:01
noisy clutch mk 3 fiesta - nicholasjpeck

Was there a resolution to this clutch issue. I have a similar noise with a 2004 1.25 Fiesta. Many thanks

Reply | Report as offensive | Link
Sun 30 May 2010 10:06
noisy clutch mk 3 fiesta - Singlish

As DP above says this is a feature of these cars, we have a 12 year old Fiesta, when the car was 1 year old, we queried this noise with the dealer, he pointed out they all did this, apparently they had just cahanged a gearbox on a similar Fiesta( for this reason) and the new one was worse!

11 years on our Fiesta is still the same the noise doesn't seem to have got worse, perhaps we are less fussy.

Andrew

Reply | Report as offensive | Link